Filmes nanométricos obtidos a plasma da mistura ácido cítrico-etilenoglicol-metal complexador
Carregando...
Data
2016-12-09
Autores
Cavalini, Eliseu Antonio [UNESP]
Título da Revista
ISSN da Revista
Título de Volume
Editor
Universidade Estadual Paulista (Unesp)
Resumo
Plasmas de gases e / ou vapores orgânicos produzem filmes finos ou pós apresentando características poliméricas, especialmente quando os plasmas são derivados de monômeros das famílias dos hidrocarbonetos alcoóis, siloxanos, silazanos, e outro. Neste trabalho, os filmes finos foram obtidos a partir da mistura de ácido cítrico-etilenoglicol-metal complexador depositado a plasma, com 13,56 MHz de radiofrequência na potência de 10 a 50 W e pressão fixada a 10 Pa. Os resultados da análise de espectroscopia de infravermelho FTIR mostrou que os grupos vibracionais dos filmes estavam preservados, mas com modificações em suas estruturas moleculares. Foram observados nos resultados obtidos por espectroscopia fotoelétrica de raios-X modificações na composição química da ligação oxigênio-carbono e oxigênio-hidrogênio com variação da potência de 10 a 50 W. A taxa de deposição dos filmes finos diminuiu de 0,10 a 0,08 nm/minuto com o aumento da potência de 10 a 50 W. As propriedades óticas das amostras como o índice de refração, coeficiente de absorção, gap ótico foram investigados por espectroscopia UV- visível. Destas análises foram possíveis obter valores n de 1,54 a 1,50 e energia do gap entre 4,75 e 4,85 eV. A técnica de ângulos de contato e foi utilizada para investigar a molhabilidade das amostras, que apresentaram caráter hidrofílico em todas as condições de deposição dos filmes. A técnica de EDS foi usada para investigar as composições químicas das amostras. Além disso, os filmes obtidos apresentaram valores de condutividade elétrica superior a 10-8 (Ωcm)-1 e constantes dielétricas entre 2,4 e 2,7.
Plasmas from gases and / or organic vapors produce thin films or powders presenting polymeric characteristics, especially when the plasmas are derived from monomers of the families of hydrocarbons, alcohols, siloxanes, silazanes, and others. In this work, thin films were obtained by citric acid / ethylene glycol / complex metal deposited by 13.56 MHz RF plasma at 10 and 50 W fixed pressure 10 Pa. FTIR spectroscopy showed that the main vibrational groups of the films were preserved, but with modifications in their molecular structures. It was observed by X –ray photoelectron spectroscopy chemical composition modifications in oxygen – carbon and oxygen – hydrogen bond while the deposition power changed from 10 to 50 W. The deposition rate of the samples decreased from 0.10 to 0.08 nm / minute while the RF power increases from 10 to 50 W. The samples optical properties as refractive index n, absorption coefficient, optical gap Eg were investigated by UV – Visible spectroscopy. From these analysis were possible to obtain values of n from 1.54 to 1.50 and Eg between 4.75 and 4.85 eV. Contact angle and surface energy measurements were used to investigate the wettability of composite Polymer films, for all depositions conditions the films presented hydrophilic character. EDS was used investigate components of the samples. Moreover, the film showed electrical conductivity values greater than 10-8(Ωcm)-1 and dielectric constant between 2.2 and 2.7.
Plasmas from gases and / or organic vapors produce thin films or powders presenting polymeric characteristics, especially when the plasmas are derived from monomers of the families of hydrocarbons, alcohols, siloxanes, silazanes, and others. In this work, thin films were obtained by citric acid / ethylene glycol / complex metal deposited by 13.56 MHz RF plasma at 10 and 50 W fixed pressure 10 Pa. FTIR spectroscopy showed that the main vibrational groups of the films were preserved, but with modifications in their molecular structures. It was observed by X –ray photoelectron spectroscopy chemical composition modifications in oxygen – carbon and oxygen – hydrogen bond while the deposition power changed from 10 to 50 W. The deposition rate of the samples decreased from 0.10 to 0.08 nm / minute while the RF power increases from 10 to 50 W. The samples optical properties as refractive index n, absorption coefficient, optical gap Eg were investigated by UV – Visible spectroscopy. From these analysis were possible to obtain values of n from 1.54 to 1.50 and Eg between 4.75 and 4.85 eV. Contact angle and surface energy measurements were used to investigate the wettability of composite Polymer films, for all depositions conditions the films presented hydrophilic character. EDS was used investigate components of the samples. Moreover, the film showed electrical conductivity values greater than 10-8(Ωcm)-1 and dielectric constant between 2.2 and 2.7.
Descrição
Palavras-chave
Ácido cítrico-etilenoglicol-metal complexador, FTIR, EDS, Citric acid-ethylene glycol-complex metal, Filmes poliméricos a plasma, Propriedades óticas e elétricas, Análises EDS, Molhabilidade, Plasma polymer films, Optical and electric properties, Wettability